Electric airplane startup Zunum chooses Safran engine turbine

[October 04, 2018]  By Eric M. Johnson

SEATTLE (Reuters) - Aircraft manufacturer Zunum, backed by Boeing Co, will use an engine turbine from France's Safran SA to power an electric motor for the hybrid regional airplane it aims to bring into service in 2022, the company said on Thursday.
 

Zunum, based near Seattle, is among several companies seeking to reduce emissions, noise and travel costs with electric planes, underscoring growing investment in lightweight propulsion systems to bring the benefits of electric-cars to the sky.

Siemens AG, Rolls-Royce Holdings PLC, and Airbus SA joined forces last year on a hybrid electric aircraft propulsion system, while Honeywell International Inc has developed a high-capacity generator that could be used for electric flight.

Zunum, which is also funded by JetBlue Airways Corp's investment arm, will offer its 12-seat, 700-mile aircraft - dubbed the ZA10 - to charter airlines, private companies and regional carriers globally, starting in 2022.

Zunum's planes will be battery powered, with a jetfuel-powered turbogenerator to extend range. It chose the Safran Helicopter Engines' Ardiden 3Z turbine over competing turbines from General Electric, Honeywell, Pratt & Whitney, and Rolls Royce.

The ZA10 will cost less than $300 million to develop, compared to the billions of dollars required to bring a traditional regional jet to market, Zunum's Chief Executive Officer Ashish Kumar told Reuters.

Norway in June tested a two-seater electric plane, built by Pipistrel in Slovenia, and predicted a start to passenger flights by 2025 as the country moves to reach a government goal of making all domestic flights in Norway electric by 2040.

"This is the future," Kumar said. "This class of aircraft is going to replace conventional airplanes over these (short-haul) distances."

Siemens' e-aircraft unit told Reuters earlier this year its system will work like a Toyota Prius: a gas-fueled engine inside the plane will spin a generator, sending electricity to small propulsion motors on the wings.

In Zunum's plane, those motors are powered by the battery packs and the turbogenerator installed near the rear of the fuselage.

Kumar said the new aircraft will deliver operating costs of 8 cents per available seat mile or $250 per hour, which is 60-80 percent lower than comparable conventional aircraft.

Zunum's prototype motor is due to be tested in early December, with an improved version flying on a test aircraft in summer 2019, Kumar said. Conversely, the Airbus, Siemens, Rolls-Royce system is scheduled to begin test flights in 2020.

(Reporting by Eric M. Johnson in Seattle)

[© 2018 Thomson Reuters. All rights reserved.]

Copyright 2018 Reuters. All rights reserved. This material may not be published, broadcast, rewritten or redistributed.  Thompson Reuters is solely responsible for this content.